PSR-SPP- 24DC/TS/SDOR4/4X1 - Extension module

2986106

PSR-TRISAFE-M relay output extension module with 4 safe relay output contacts (choice of 4 single-channel or 2 two-channel relay contacts), 4 signal outputs; up to SIL 3, Cat. 4/PL e, SIL 3, EN 50156, pluggable Push-in terminal block

Free download available. Downloads

Note on application
Note on application	Only for industrial use

Product type	Safety device
Application	PSR-TRISAFE-M extension module
Control	1 and 2 channel
Insulation characteristics: Air clearances and creepage distances between the power circuits
Overvoltage category	III
Pollution degree	2
Times
Response time	max. 50 ms
Recovery time	< 10 s

Maximum power dissipation for nominal condition	3932 mW (up to 40°C ambient temperature, at m = 4, n = 4, I_load = 4 A, I_signal = 50 mA)
	1532 mW (up to 55°C ambient temperature, at m = 4, n = 4, I_load = 1 A, I_signal = 50 mA)
Nominal operating mode	100% operating factor
Interfaces	DIN rail TBUS for connection to the master module, supplied as standard
Air clearances and creepage distances between the power circuits
Rated insulation voltage	250 V AC
Rated surge voltage/insulation	4 kV / basic insulation between output contact current paths (13/14, 23/24, 33/34, 43/44); 6 kV / safe isolation, reinforced insulation between output contact current paths (13/14, 23/24, 33/34, 43/44) and the other circuits
Supply
Rated control circuit supply voltage U_S	18 V DC ... 30 V DC (Incl. all tolerances, incl. residual ripple)
Rated control circuit supply voltage U_S	24 V DC (Electrical supply via PSR-TBUS)
Rated control supply current I_S	Electrical supply via PSR-TBUS
	74 mA (At 24 V DC, relay outputs set)
	54 mA (At 24 V DC, relay outputs not set)
Protective circuit	Yes, within the scope of the operating voltage limits
Status display	1 x LED (green) , 1 x LED (red)

Maximum switching voltage	250 V AC/DC
	24 V DC
Minimum switching voltage	5 V AC/DC
Limiting continuous current	4 A (see derating curve)
Maximum inrush current	6 A
Inrush current, minimum	5 mA
Switching capacity (3600/h cycles)	3 A (230 V (AC 15))
	5 A (24 V (DC13))
Output fuse	6 A gL/gG
Response time	max. 50 ms
Relay
Output description	Relay contacts, safety-related N/O contacts
Number of outputs	4 (Single-channel)
	2 (Two-channel, connected in pairs)
Contact switching type	4 relay output contacts
Contact material	AgSnO₂ (From HW03) AgCuNi +0.2 ... 0.4 μm Au (up to HW02)
Switching voltage	min. 12 V AC/DC (from HW 03)
	min. 5 V AC/DC (Up to HW02)
	max. 250 V AC/DC (For modules from HW03, see Section “Relay data” in the user manual.)
Switching current	min. 3 mA (from HW 03)
	min. 5 mA (Up to HW02)
Switching power	min. 60 mW
Switching capacity in accordance with IEC 60947-5-1	2 A (AC15)
	4 A (DC13)
Limiting continuous current	4 A (see to derating)
Mechanical service life	10x 10⁶ cycles
Output fuse	4 A (gL/gG)
Status display	4 x LED (green)
Signal
Output description	digital
Number of outputs	4
Voltage	24 V DC (Supply via A1/A2)
Limiting continuous current	50 mA
Protective circuit	Yes, within the scope of the operating voltage limits
Short-circuit protection	Yes

Connection technology
pluggable	yes
Conductor connection
Connection method	Push-in connection
Conductor cross-section rigid	0.2 mm² ... 1.5 mm²
Conductor cross-section, flexible, with ferrule, with plastic sleeve	0.25 mm² ... 1.5 mm² (only together with CRIMPFOX 6)
Conductor cross-section, flexible, with ferrule, without plastic sleeve	0.25 mm² ... 1.5 mm² (only together with CRIMPFOX 6)
Conductor cross-section AWG	24 ... 16
Stripping length	8 mm

Width	22.5 mm
Height	112 mm
Depth	114.5 mm

Color	yellow
Housing material	Polyamide PA non-reinforced

Safety data
Stop category (EN 60204-1)	0
Safety data: EN ISO 13849
Performance level (PL)	c (1-channel parameterization)
	e (2-channel parameterization)
Safety data: EN 50156
Safety Integrity Level (SIL)	max. 3 (Reference IEC 61508)
Safety data: IEC 61508 - High demand
Safety Integrity Level (SIL)	1 (1-channel parameterization)
	3 (2-channel parameterization)
Safety data: IEC 61508 - Low demand
Safety Integrity Level (SIL)	1 (1-channel parameterization)
	3 (2-channel parameterization)
Safety data: EN IEC 62061
Safety Integrity Level (SIL)	1 (1-channel parameterization)
	3 (2-channel parameterization)

Ambient conditions
Degree of protection	IP20
Min. degree of protection of inst. location	IP54
Ambient temperature (operation)	-20 °C ... 55 °C
Ambient temperature (storage/transport)	-20 °C ... 70 °C
Maximum altitude	max. 2000 m (See Appendix "Using PSR-TRISAFE modules at altitudes greater than 2000 m above sea level")
Max. permissible humidity (storage/transport)	75 % (On average, 85 % occasionally)
Max. permissible relative humidity (operation)	75 % (On average, 85 % occasionally)
Shock (operation)	10g (Δt = 11 ms, three shocks in each space direction)
	10g (Δt = 16 ms, continuous shock, 1000 shocks in each space direction)
Vibration (operation)	2g
Air pressure (operation)	70 kPa ... 108 kPa (up to 3000 m above sea level)
Air pressure (storage/transport)	66 kPa ... 108 kPa (up to 3500 m above sea level)

Air clearances and creepage distances between the power circuits
Standards/regulations	DIN EN 50178

Mounting type	DIN rail mounting
Mounting position	On horizontal DIN rail

Item number	2986106
Packing unit	1 pc
Minimum order quantity	1 pc
Sales key	DNA
Product key	DNA332
GTIN	4046356536547
Weight per piece (including packing)	200 g
Weight per piece (excluding packing)	140 g
Customs tariff number	85371098
Country of origin	DE

Compatible products

Accessories

PHOENIX CONTACT Trading LLC

Twin Tower Building No. 3279, 6th Floor, King Abdullah Branch Road, Al Quds District, Riyadh 13214, Kingdom of Saudi Arabia, Short Address Code: RFQA3279

Ask a Question +966579880822 info-sa@phoenixcontact.com

EU RoHS
Fulfills EU RoHS substance requirements	Yes
Exemption	7(a), 7(c)-I
China RoHS
Environment friendly use period (EFUP)	EFUP-50 An article-related China RoHS declaration table can be found in the download area for the respective article under "Manufacturer declaration". For all articles with EFUP-E, no China RoHS declaration table issued and required.
EU REACH SVHC
REACH candidate substance (CAS No.)	Lead (CAS: 7439-92-1)
		2,2',6,6'-tetrabromo-4,4'-isopropylidenediphenol (CAS: 79-94-7)

Automate

Connect

Mark, assemble, and install

Supply, charge, and protect

Switch, Measure and Monitor

PSR-SPP- 24DC/TS/SDOR4/4X1 - Extension module

2986106

Product details

ECLASS

ETIM

UNSPSC

cULus Listed

Functional Safety

Compatible products

Automate

Connect

Mark, assemble, and install

Supply, charge, and protect

Switch, Measure and Monitor

PSR-SPP- 24DC/TS/SDOR4/4X1 - Extension module 2986106

Product details

ECLASS

ETIM

UNSPSC

Compatible products

PSR-TRISAFE STARTER KIT - Starter kit 2986300

IFS-CONFSTICK - Memory block 2986122

CABLE-USB/MINI-USB-3,0M - USB cable 2986135

SAFECONF - Configuration package 2986119

ME 22,5 TBUS 1,5/ 5-ST-3,81 GN - DIN rail bus connector 2707437

PSR-TBUS - DIN rail bus connector 2890425

PSR-FTB/20/86 - Filter terminal block 2904477

PSR-FTB/1.5/11.5 - Filter terminal block 2904476

COPYSTATION - IFS - Copy and delete station 2901985

EM-CAN-GATEWAY-IFS - Data interface 2901504

EM-MODBUS-GATEWAY-IFS - Data interface 2901528

EM-ETH-GATEWAY-IFS - Data interface 2901988

EM-PNET-GATEWAY-IFS - Data interface 2904472

EM-PB-GATEWAY-IFS - Data interface 2297620

PSR-TBUS - 1PCS - DIN rail bus connector 1326060

PSR-SPP- 24DC/TS/SDOR4/4X1 - Extension module

2986106